Drolet ECO-45 Spécifications

READ AND KEEP THIS MANUAL FOR REFERENCE 45725A Printed in Canada 03-06-2014 Installation and Operation Manual Eco-65 Safety tested according to U

Eco-65 Installation and Operation Manual 10 2.2 Regulations Covering Pellet Stove Installation When installed and operated as described in these

Eco-65 Installation and Operation Manual 100 APPENDIX F: OPTIONAL HOT AIR DISTRIBUTION KIT (AC01330) The hot air distribution kit AC01330 is avail

Eco-65 Installation and Operation Manual 101 This hot air plenum kit contains the following parts: (A) -49068 2x (B) -PL62444 1x (C) -SE62443 1

Eco-65 Installation and Operation Manual 102 DROLET LIMITED LIFETIME WARRANTY The warranty of the manufacturer extends only to the original consum

Eco-65 Installation and Operation Manual 11 2.3 Before Operating Your Stove Some minor installation and adjustment are required prior to use: 

Eco-65 Installation and Operation Manual 12 3 Clearances to Combustible Material The clearances shown in this section have been determined by tes

Eco-65 Installation and Operation Manual 13 3.3 Floor Protection For floor protection clearances refer to the following table. FLOOR PROT

Eco-65 Installation and Operation Manual 14 4 Venting system 4.1 General Even though the chimney draft is mechanical, a suitable venting system wi

Eco-65 Installation and Operation Manual 15  2 horizontal run of 1’ = (2 X 1’) X 1’ = 2’ of EVL  1 elbow 90° or "Tee" = 5’ of EVL 

Eco-65 Installation and Operation Manual 16 WARNING: To reduce the risk of smoke spillage there should always be at least one foot of vertical ris

Eco-65 Installation and Operation Manual 17 4.4.1 Permitted Termination Location Refer to NFPA 211 (USA) or CSA B365 (Canada) for rules for the di

Eco-65 Installation and Operation Manual 18 United States:  Not Less than 36’’ (91 cm) above any forced air inlet located within 10 feet (305 cm

Eco-65 Installation and Operation Manual 19 4.5.2 Through Wall Installation (Main Floor or Basement) 1. Position stove following clearances gi

Eco-65 Installation and Operation Manual 2 THANK YOU FOR CHOOSING THIS DROLET PELLET STOVE As one of North America’s largest and most respected pe

Eco-65 Installation and Operation Manual 20 4.5.3 Through Roof Installation 1. Position stove following clearances given in Section 3.2: Minimum

Eco-65 Installation and Operation Manual 21 4.5.4 Through a Factory Built Chimney To make an installation through a factory built chimney, run a

Eco-65 Installation and Operation Manual 22 4.5.5 Through an Existing Masonry Fireplace 1. Position stove, following clearances shown in Section

Eco-65 Installation and Operation Manual 23 4.5.6 Through an Existing Masonry Chimney 1. Position stove following clearances shown in Section 3

Eco-65 Installation and Operation Manual 24 PART B - OPERATION 4.6 General Information 4.7 Operation Warnings, Cautions and Recommendations  KE

Eco-65 Installation and Operation Manual 25  THE VIEWING DOOR MUST BE CLOSED AND LATCHED AT ALL TIMES DURING OPERATION. THE ASH DRAWER ACCESS P

Eco-65 Installation and Operation Manual 26  THE STOVE WILL NOT OPERATE DURING A POWER OUTAGE. IF AN OUTAGE DOES OCCUR, CHECK THE STOVE FOR SMOK

Eco-65 Installation and Operation Manual 27 4.7.1 Zone Heating and How to Make It Work for You Your new pellet stove is a space heater, which mea

Eco-65 Installation and Operation Manual 28 4.8.2 Where to Store Bags of Pellets We recommend that you store your bags of pellets in a dry and we

Eco-65 Installation and Operation Manual 29 Control panel screen Operation mode : OFF MANUAL THERMOSTAT:Thermostatic control (optional)Butt

Eco-65 Installation and Operation Manual 3 Table of contents 1 Introduction ...

Eco-65 Installation and Operation Manual 30 5.1.2 Fuel Feed Button When the “Fuel Feed” button is pushed the stove will feed pellets continuous

Eco-65 Installation and Operation Manual 31 5.2 Adjustments 5.2.1 Selecting the Combustion Level (Heat Rate) The heat input of the stove varies b

Eco-65 Installation and Operation Manual 32 6.2 Everyday Startup Before starting the stove, make sure there is enough pellets in the hopper and th

Eco-65 Installation and Operation Manual 33 To use this mode, the button must be pushed to “Thermostat” upon starting the stove. The heat settin

Eco-65 Installation and Operation Manual 34 maintenance has been done properly. Press the and the buttons and hold simultaneously for 2 second

Eco-65 Installation and Operation Manual 35 7 Maintenance 7.1 Stove Maintenance 7.1.1 Recommended Maintenance Schedule Use this as a guide when u

Eco-65 Installation and Operation Manual 36 OR OTHERWISE LOCALLY DISPERSED, THEY SHOULD BE RETAINED IN THE CLOSED CONTAINER UNTIL ALL CINDERS HAVE

Eco-65 Installation and Operation Manual 37 Using the provided sweeping rod, sweep up and down each exchanger. Make sure you go all the way down t

Eco-65 Installation and Operation Manual 38 1) Open the door and turn the lock (A) that can be found above the door opening. 2) Once the baffl

Eco-65 Installation and Operation Manual 39 4) Take out the baffle from the combustion chamber. IT IS HIGHLY RECOMMENDED TO CLEAN THE EXHAUST CH

Eco-65 Installation and Operation Manual 4 7 Maintenance ...

Eco-65 Installation and Operation Manual 40 Using a Philips or Robertson screwdriver, remove both clean-out traps by unlocking them. Push the scre

Eco-65 Installation and Operation Manual 41 7.1.4 Cleaning the Burn Pot The burn pot must remain clean and the holes should not be obstruct

Eco-65 Installation and Operation Manual 42 2. The burn pot simply sits onto the air intake channel. You must lift to remove it from the stove. T

Eco-65 Installation and Operation Manual 43 Verify that the clean out trap gasket is still in good condition, replace it if needed (3/16’’ black

Eco-65 Installation and Operation Manual 44 WARNING: ASH PAN MUST BE IN PLACE AND THE ASH PAN ACCESS DOOR MUST BE KEPT CLOSED AT ALL TIMES WHEN TH

Eco-65 Installation and Operation Manual 45 7.1.9 Door Gasket Maintenance It is important to maintain the door gasket in good condition. After a

Eco-65 Installation and Operation Manual 46 7.2 Venting System Maintenance CAUTION: REGULARLY EXAMINE THE VENTING SYSTEM, THE JOINTS, AND THE SEA

Eco-65 Installation and Operation Manual 47 8 Troubleshooting When you have issues with your stove, your first reaction may be to call technical s

Eco-65 Installation and Operation Manual 48 8.2 Testing a Component If you suspect that an electrical component to be defective, you can test it

Eco-65 Installation and Operation Manual 49 Push the control key to proceed. The frequency of the power source is displayed. Push any control ke

Eco-65 Installation and Operation Manual 5 1 Introduction 1.1 About Pellet Heating Pellet stoves offer a dramatic improvement in the convenience

Eco-65 Installation and Operation Manual 50 Displays the temperature read by the thermistor. Push any control key to proceed. Convection blower te

Eco-65 Installation and Operation Manual 51 8.3 Main Error Codes, Possible Causes and Solutions WARNING: RISK OF ELECTRICAL SHOCK. IF YOU NEED TO

Eco-65 Installation and Operation Manual 52 ALARM CODES CHART MESSAGE CORRESPONDING WARNING Pressure switch warning. Warning caused by the autom

Eco-65 Installation and Operation Manual 53 8.3.1 P Code STOVE SHUTS OFF AND APPEARS ON CONTROL BOARD Possible Causes: Possible Remedies: (Unpl

Eco-65 Installation and Operation Manual 54 check fuse F4 and F5 on the control board. A defective fuse will be darkened or will have a broken fil

Eco-65 Installation and Operation Manual 55 4. The stove needs maintenance. Refer to Section 7: Maintenance. 5. The burn pot is not installed p

Eco-65 Installation and Operation Manual 56 THIS PELLET STOVE IS EQUIPED WITH MULTIPLE DEVICES TO ENSURE YOUR SAFETY. IF A WARNING ERROR CODE STOP

Eco-65 Installation and Operation Manual 57 8.3.3 E Code STOVE SHUTS OFF AND DISPLAYS WARNING CODE Possible Causes: Possible Remedies: (Unplug

Eco-65 Installation and Operation Manual 58 that could have caused a jam. Clean the auger housing thoroughly to remove all pellet dust. 5. The

Eco-65 Installation and Operation Manual 59 HOPPER AUGER A Screws B Auger and motor assembly C gasket BURN POT AUGER A Screws B Auger and mot

Eco-65 Installation and Operation Manual 6 1.2 Eco-65 Specifications Fuel Type Wood pellets Test Standards (safety) ULC S627, ASTM E1509 and UL

Eco-65 Installation and Operation Manual 60 8.3.4 L Code STOVE FEEDS PELLETS, BUT WILL NOT IGNITE AND APPEARS ON THE CONTROL BOARD Possible Cau

Eco-65 Installation and Operation Manual 61 to keep the exhaust temperature high enough. To resolve the situation increase feed rate or replace th

Eco-65 Installation and Operation Manual 62 8.3.6 N Code THE STOVE FUNCTIONS BUT DISPLAYS WARNING CODE Possible Cause: Possible Remedy:1. A re

Eco-65 Installation and Operation Manual 63 8.3.9 A Code STOVE FEEDS PELLETS, BUT WILL NOT IGNITE AND APPEARS ON THE CONTROL BOARD Possi

Eco-65 Installation and Operation Manual 64 2. The wiring harness shorted. Make sure the auger motor wiring is properly connected and not shorte

Eco-65 Installation and Operation Manual 65 8.3.11 Auger Motor Stops Momentarily AUGER MOTOR STOP FEEDING PELLETS AND COMES BACK ON Possible Cause

Eco-65 Installation and Operation Manual 66 filled the tube around the igniter. Refer to Section 7: Maintenance. Also, make sure that recommended

Eco-65 Installation and Operation Manual 67 9 Wiring Diagram

Eco-65 Installation and Operation Manual 68 10 Access to Fuses WARNING: UNPLUG THE STOVE BEFORE CHANGING THE FUSES. All fuses are located inside

Eco-65 Installation and Operation Manual 69 LETTER FUSE FUNCTION AMPERAGE A MAIN BOARD FUSE 7.5A B CONVECTION BLOWER 5A C COMBUSTION BLOWER 3A

Eco-65 Installation and Operation Manual 7 1.3 Overall Exterior Dimensions A FRESH AIR INLET B EXHAUST

Eco-65 Installation and Operation Manual 70 11 Components Location LETTER COMPONENT A HEAT EXCHANGER TUBES B BURN POT C IGNITOR D C

Eco-65 Installation and Operation Manual 71 12 Blower Replacement CONVECTION BLOWER Unscrew screw A (1), slightly pivot the fan upward then parti

Eco-65 Installation and Operation Manual 72 COMBUSTION BLOWER Remove the 9 screws (A) and the bottom grille (B). Unlatch the clamps (C). Remove t

Eco-65 Installation and Operation Manual 73 EXHAUST BLOWER Remove the left panel. Unplug the connections (A) and (B). Unplug the silicone tu

Eco-65 Installation and Operation Manual 74 Remove the clamp (D). With a Philips screwdriver, unlock and remove the access panel (E).

Eco-65 Installation and Operation Manual 75 Remove the nuts (F) located in the opening of the trapdoor. Remove the duct assembly (G).

Eco-65 Installation and Operation Manual 76 Remove the bolts (H) and nuts (I) to remove the exhaust blower (J)

Eco-65 Installation and Operation Manual 77 13 L-250 and F-160 Thermal Switch Replacement L-250 1. Remove both retaining screws (A) holding the

Eco-65 Installation and Operation Manual 78 Remove the faulty thermal switch. Replace new thermal switch (D) underneath the bracket (B) by means o

Eco-65 Installation and Operation Manual 79 14 Exploded View and Replacement Parts SECTION A

Eco-65 Installation and Operation Manual 8 PART A – INSTALLATION 2 Installation Safety Information 2.1 Installation Warnings, Cautions and Recom

Eco-65 Installation and Operation Manual 80 SECTION B

Eco-65 Installation and Operation Manual 81 SECTION C

Eco-65 Installation and Operation Manual 82 SECTION D SECTION E

Eco-65 Installation and Operation Manual 83 SECTION F SECTION G

Eco-65 Installation and Operation Manual 84 SECTION H SECTION I

Eco-65 Installation and Operation Manual 85 SECTION J

Eco-65 Installation and Operation Manual 86 IMPORTANT: THIS IS DATED INFORMATION. When requesting service or replacement parts for your stove, ple

Eco-65 Installation and Operation Manual 87 # Item Description Qty 36 30799 STEEL ROUND KNOB, 3/8"-16 THREADED 1 37 30800 FULLY THREA

Eco-65 Installation and Operation Manual 88 # Item Description Qty 77 PL64459 MOTHER BOARD HOUSING COVER 1 78 49006 3/8'' X 24&q

Eco-65 Installation and Operation Manual 89 APPENDIX A: HORIZONTAL AND VERTICAL VENT CHART Possible Vertical vent length (feet) Possible Horiz

Eco-65 Installation and Operation Manual 9  DO NOT INSTALL A FLUE DAMPER IN THE EXHAUST VENTING SYSTEM OF THIS UNIT.  DO NOT CONNECT THIS STOV

Eco-65 Installation and Operation Manual 90 Instead, if the installation consisted of a horizontal vent coming out at the back of the stove on a t

Eco-65 Installation and Operation Manual 91 APPENDIX B: FLAME CARACTERISTICS Efficient flame An efficient flame should be bright but not too vigor

Eco-65 Installation and Operation Manual 92 APPENDIX C: INSTALLING A THERMOSTAT (AC05558) Using a thermostat will help you maintain a constant tem

Eco-65 Installation and Operation Manual 93 Wired thermostat Before installing the thermostat, unplug the power cord from the power outlet. First,

Eco-65 Installation and Operation Manual 94 Wireless thermostat If you are using a wireless thermostat or a hand held thermostatic remote control,

Eco-65 Installation and Operation Manual 95 APPENDIX D: MOBILE HOME INSTALLATION Anchor the stove WARNING: FOR MOBILE HOME INSTALLATION, IT IS MAN

Eco-65 Installation and Operation Manual 96 A Fresh air intake B Tee C Pellet pipe length and/or slip section D Ceiling support E Attic insulatio

Eco-65 Installation and Operation Manual 97 APPENDIX E: COMBUSTION AIR SUPPLY WARNING: FOR MOBILE HOME INSTALLATION, IT IS MANDATORY TO CONNECT TH

Eco-65 Installation and Operation Manual 98 To complete the installation, make a hole of1/4" to 1/2" (6 mm à 13 mm) bigger than the insu

Eco-65 Installation and Operation Manual 99 Sources of Outside Combustion Air WARNING: IT IS FORBIDDEN TO DRAW COMBUSTION AIR FROM A BASEMENT, AN