Drolet PYROPAK E.P.A. WOOD STOVE Spécifications

READ AND KEEP THIS MANUAL FOR REFERENCE 45397A Printed in Canada 24-07-2014 Installation and Operation Manual Pyropak US ENVIRONMENTAL PROTECTIO

Pyropak Installation and Operation Manual 10 The smoke released from wood when it is heated contains about half of the energy content of the fuel.

Pyropak Installation and Operation Manual 11 3 Fuel 3.1 Materials That Should Not be Burned • GARBAGE OF ANY KIND, • COAL OR CHARCOAL, • TREATE

Pyropak Installation and Operation Manual 12 wouldn’t hold a fire overnight unless they were fed large pieces of hardwood. That is no longer true.

Pyropak Installation and Operation Manual 13 3.2.5 How to Dry Firewood Firewood that is not dry enough to burn is the cause of most

Pyropak Installation and Operation Manual 14 3.2.6 Judging Firewood Moisture Content You can find out if some firewood is dry enough to burn by u

Pyropak Installation and Operation Manual 15 4 Operating Your Stove 4.1 The use of a fire screen. This stove has been tested for use with an

Pyropak Installation and Operation Manual 16 4.3.1 Conventional Fire Starting The conventional way to build a wood fire is to bunch up 5

Pyropak Installation and Operation Manual 17 4.3.3 Two Parallel Logs Place two spit logs in the firebox. Place a few sheets of twisted newspaper

Pyropak Installation and Operation Manual 18 IF YOU MUST OPEN THE DOOR WHILE THE FUEL IS FLAMING, OPEN THE AIR CONTROL FULLY FOR A FE

Pyropak Installation and Operation Manual 19 4.4.4 Firing Each New Load Hot Place the new load of wood on and behind the charcoal. Close the door

Pyropak Installation and Operation Manual 2 THANK YOU FOR CHOOSING THIS DROLET WOOD STOVE As one of North America’s largest and most resp

Pyropak Installation and Operation Manual 20 4.4.6 Building Different Fires for Different Needs Using the air control is not the only w

Pyropak Installation and Operation Manual 21 4.4.6.3 High Output Fires for Cold Weather When the heat demand is high during cold weather, you’ll

Pyropak Installation and Operation Manual 22 4.4.6.5 North-South Fires Versus East-West Fires In fireboxes that are roughly square, wood can be l

Pyropak Installation and Operation Manual 23 5 Maintaining Your Wood Heating System 5.1 Stove Maintenance Your new stove will give many years of

Pyropak Installation and Operation Manual 24 5.1.2 Door adjustment In order for your stove to burn at its best efficiency, the door must provide

Pyropak Installation and Operation Manual 25 5.1.3 Replacing the Door Gasket It is important to maintain the gasket in good condition. After a ye

Pyropak Installation and Operation Manual 26 Do not abuse the glass door by striking or slamming shut. Do not use the stove if the glass is broken

Pyropak Installation and Operation Manual 27 5.2.3 Cleaning the Chimney Chimney cleaning can be a difficult and dangerous job. If you don’t

Pyropak Installation and Operation Manual 28 PART B - INSTALLATION 6 Safety Information 6.1 Summary of Installation Cautions and Warnings • THE

Pyropak Installation and Operation Manual 29 6.2 Regulations Covering Stove Installation When installed and operated as described in these instru

Pyropak Installation and Operation Manual 3 Table of content PART A - OPERATION AND MAINTENANCE ... 6 1 Safety Inform

Pyropak Installation and Operation Manual 30 7 Clearances to Combustible Material The clearances shown in this section have been determin

Pyropak Installation and Operation Manual 31 CLEARANCES (SINGLE WALL PIPE) CANADA USA A 15½" (394 mm) 15" (381 mm) B 18" (457

Pyropak Installation and Operation Manual 32 Clearances to combustible materials and floor protection

Pyropak Installation and Operation Manual 33 7.3 Floor protector If the stove is to be installed on top of a combustible floor, it must be guarde

Pyropak Installation and Operation Manual 34 7.4 Reducing Wall and Ceiling Clearances Safely It is often desirable to reduce the minimum i

Pyropak Installation and Operation Manual 35 7.4.2 Table of Clearance Reduction Percentages Type of shield Clearances may be reduced by these p

Pyropak Installation and Operation Manual 36 8 The Venting System 8.1 General The venting system, made up of the chimney and the connecting pip

Pyropak Installation and Operation Manual 37 8.2.2 Masonry Chimneys The stove may also be connected to a masonry chimney, provided the chimney

Pyropak Installation and Operation Manual 38 8.4 The Relationship Between the Chimney and the House Because the venting system is the engine th

Pyropak Installation and Operation Manual 39 There are two reasons why the chimney in the house at right will cold backdraft when it

Pyropak Installation and Operation Manual 4 4.4.6 Building Different Fires for Different Needs ...

Pyropak Installation and Operation Manual 40 8.6 Installing the Chimney Connector The chimney connector is the single or double wall pipe install

Pyropak Installation and Operation Manual 41 The rules below are based on those found in the CSA B365 installation code. Please care

Pyropak Installation and Operation Manual 42 Appendix 1: Installing the Fresh Air Intake Kit (AC01331) The installation instructions are pro

Pyropak Installation and Operation Manual 43 Appendix 2: Installation and Use of Optional Air Circulation Fan and Thermodisc An optional

Pyropak Installation and Operation Manual 44 When using the optional fan, allow the stove to reach operating temperature (approximately

Pyropak Installation and Operation Manual 45 Appendix 3: Installing the Fire Screen (AC01318) Open the door. Hold the fire screen by the two han

Pyropak Installation and Operation Manual 46 Appendix 4: Exploded Diagram and Parts List

Pyropak Installation and Operation Manual 47 # Item # Description Qty/ Unit 1 AC01318 FIRE SCREEN 1 2 30569 ROUND WOODEN HANDLE BLACK 2 3

Pyropak Installation and Operation Manual 48 DROLET LIMITED LIFETIME WARRANTY The warranty of the manufacturer extends only to the orig

Pyropak Installation and Operation Manual 5 8.6 Installing the Chimney Connector...

Pyropak Installation and Operation Manual 6 PART A - OPERATION AND MAINTENANCE Please see Part B for installation instructions. 1 Safety Informat

Pyropak Installation and Operation Manual 7 2 General Information 2.1 Pyropak Specifications Fuel Type Cordwood Test Standards (safety) ULC

Pyropak Installation and Operation Manual 8

Pyropak Installation and Operation Manual 9 2.2 Zone Heating and How to Make it Work for You Your new Pyropak wood stove is a space heater, whi